Tag Archives: portage food

How To Dehydrate Lamb Shepherd's Pie for Back Country Camping

How to Dehydrate Shepherd’s Pie for Backcountry Camping

How to Dehydrate Shepherd's Pie for Backcountry Camping

How To Dehydrate Lamb Shepherd’s Pie for Backcountry Camping

One of my favourite activities to do in the summer is canoe tripping.  I love all the preparation that goes into planning the ultimate portage trip including, the food!  Way back when I wrote a post on how to dehydrate food.  The post covered the basic dehydration process as well as recipes for chili, stew, beef jerky and a holiday chicken dinner.  I’ve since posted recipes for beef brisket and pad thai.  This latest dehydrated meal is my most successful to date.  My Lamb Shepherd’s Pie with Sweet Potato Topping is one of my favourite recipes so I’m  so excited to share how to dehydrate Shepherd’s pie for backcountry camping!

How To Dehydrate Lamb Shepherd's Pie for Back Country Camping

How To Dehydrate Lamb Shepherd’s Pie for Backcountry Camping

Shepherd’s pie is really easy to dehydrate and rehydrates beautifully.  I use lamb in my Shepherd’s pie which is rich and fatty – an ideal candidate for dehydration as fatty meats are less tough when rehydrated.  The potato topping is easy to control, dehydrates quickly and evenly and also rehydrates well.  

The dish is deconstructed for the dehydration process and you will be dehydrating the protein and the topping separately. As per my tips in my original dehydration post, be sure to chop the onions, carrots, garlic and gherkins as finely as possible for an even dehydration. 

Prepare the recipe as per usual up to step 13 (excluding preheating the oven).  Instead of preheating your oven, wrap your dehydrator trays in plastic wrap, making sure to cut out a hole in the middle and allowing some space along the edges for air to circulate. 

How To Dehydrate Lamb Shepherd's Pie for Back Country Camping

How To Dehydrate Lamb Shepherd’s Pie for Backcountry Camping

After mixing in the gerkins to the meat mixture, spread the meat evenly onto the plastic wrap.  Then spread the sweet potato/potato mixture onto the remaining trays.  I managed to fit the whole recipe in one batch – three trays for the protein and two trays for the topping.  Close your dehydrator and set it for 8 hours or until the food is completely dry and chip-like with no wet spots.  Be sure to rotate the trays every few hours or so for an even dehydration.

How To Dehydrate Lamb Shepherd's Pie for Back Country Camping

How To Dehydrate Lamb Shepherd’s Pie for Backcountry Camping

How To Dehydrate Lamb Shepherd's Pie for Back Country Camping

How To Dehydrate Lamb Shepherd’s Pie for Backcountry Camping

Package the lamb and potatoes in separate ziplock bags and that’s it!  You now have a delicious meal ready for your next back country trip.  To rehydrate, simply soak in water, covering the food completely for at least 30 minutes.  Heat the lamb and potatoes in separate pots, adding water as necessary until fully hydrated.  Assemble your Shepherd’s pie in the great outdoors and enjoy!

How To Dehydrate Lamb Shepherd's Pie for Back Country Camping

How To Dehydrate Lamb Shepherd’s Pie for Backcountry Camping

How To Dehydrate Lamb Shepherd's Pie for Back Country Camping

How To Dehydrate Lamb Shepherd’s Pie for Backcountry Camping

What is your favourite back country meal?  What recipes have you tried to dehydrate?  I hope you enjoy my Lamb Shepherd’s Pie!

Dehydration Portage Project 2010

Last year I went portaging for the first time – after camping my whole life I can’t believe I never went portaging before!  The experience was amazing…but the dehydrated food we bought was, well, it was borderline edible.  I don’t care where I am, bad food is unacceptable!  So this year I took matters into my own hands and got a dehydrator (well actually I added to my registry heh heh), and thus my Dehydration Portage Project 2010 was born!  I have 10 days until the trip, 4 main courses to dehydrate and test for 4 people.

Our full menu is the following with the meals to be dehydrated in red:

Breakfast: Boost and oatmeal

Lunch: Clam chowder, Irish Beef Stew, Ramen w/Beef Jerky

Dinner: Turkey Chili and Bannock Bread, Swiss Chalet dinner (chicken w/chalet dipping sauce, mashed potatoes, gravy & stuffing)

Drinks/Snacks: Dried apples & bananas, beef jerky, Fruit-To-Go, trail mix, Gatorade, Vodka/Tang & Kool Aid, Lara bars, energy goo, Pringles (great after a long portage – restabilize your salt content!), hot chocolate, Smores (marshmellows, teddy grahams and individually wrapped Lindt chocolate squares), coffee (instant coffee, creamer & sweetener packets), freeze dried ice cream, hot dogs (will keep for one day), pepperettes.


Dehydrating machine, syran wrap, masher, spatula,  hand blender, food processor, slow cooker, ziplock bags, collander + a lot of prep time!

On site: salt, pepper, chicken/beef/vegetable broth, small stove, pot + large spoon, purified water.


First up: my favourite turkey chili recipe.  I’ve read that chili is pretty easy to dehydrate and tastes pretty good when rehydrated.  I’ve also read that beans are a LOT more potent when they are rehydrated…urm…how bad can it be?  Some people dehydrate all the ingredients separately, but I don’t have time for that.  I’m mincing all the ingredients in a food processor instead of chopping them up so that I can evaporate as much water as possible during the cooking process and so that I will have a nice  thick, smooth layer of chili when spread out in the dehydrator.


Dehydration Portage Project 2010

Food processed ingredients for turkey chili

The Recipe for Turkey Chili – modified for dehydrating


1 package ground turkey or chicken

1 medium onion – finely processed

2 zucchini – finely processed and drained

2 x green peppers – finely processed and drained

2 x carrots – finely processed

2 x 28 oz cans crushed tomatoes

1 x 15 oz can black beans (drained and rinsed)

package of chili seasoning (ie. Club House)

juice from one lime 

2 x heaping spoonfuls of cocoa powder

sea salt and ground pepper to taste

In a large pot over medium heat brown turkey and onion.  Mash up turkey with a potato masher to get as small bits as possible.  Add onion, zucchini, green pepper, carrot and cook for a couple of minutes, stirring constantly.  Add tomotoes, beans, [broth] seasoning, lime juice, cocoa and salt and pepper to taste.  Simmer over low heat for 30 minutes, stirring occasionally until vegetables (especially the carrot) are tender.

Dehydration Portage Project 2010DEHYDRATING

For dehydrating anything liquid, first syran wrap your food trays.  IMPORTANT: do not syran wrap the whole tray.  Make sure the middle hole is not covered and allow a couple of vents along the edges to be uncovered so that the heat can circulate evenly.  This may seem obvious, but the first time I dehydrated my chili I covered the whole tray and the chili was still very wet after 8 hrs.  After almost a full day in the dehydrator, mold started to form.  Try to use as minimal syran wrap as possible so that no wrap is hanging off the sides of the trays and that some of the vents are still free – good circulation is key.

I have 5 trays in my dehydration machine, and one tray almost equals one portion, depending on how thick the food is.  Try not to add any extra water to your meal while cooking, as you don’t want your food to be too thin on the dehydrator, making your portions very small.  Ideally you want a controlled substance that can be spread out thin with a spatula. Over five trays, this will most likely equal 4 solid portions (2 cups each).

Sometimes, you may want to drain your food, unless it has been well blended.  The chili could use a bit of draining, because of all the vegetables, a lot of water is released.  If necessary, half the chili through a colander.  Do not drain too much, you don’t want to lose all the yummy chili sauce!  Carefully ladle one portion onto each tray of the dehydrator, being careful to not spill any over the syran wrap and spreading the chili as flat as possible with a spatula.

My dehydrator does not have any heat control – just an on/off switch.  I dehydrated the chili for 8 hours until it was completely dry.  The dehydration process should not take longer then 8-9hrs, otherwise your food is too thick. They say you should dehydrate your food until it becomes a leathery texture, which works for fruit but for meals I feel as though you run the risk of wet spots, and that will lead to mold forming on your trip.  It’s better to overhydrate then to underhydrate. I’m sure you’re killing a lot of nutrients this way, but again if it’s mold vs. vitamins, I’ll just bring some Greens + powder with me!  Unless you vacuum seal your food, I would dehydrate your food until it is crispy, or until there are no damp areas on your food, being sure to check the beans and turkey by mushing a little bit apart with a knife.

Dehydration Portage Project 2010

Dehydrated turkey chili

Just to be safe, I left a tester chili in a ziplock bag out in my house for a couple of days, and then rehydrated it and consumed it.  No mold, rehydrated beautifully, tasty with no side effects.  Looking good!


As soon as you arrive on site, dump your dehydrate food into a pot and add enough water so that it just skims the surface of the food.  Allow the food to soak for a good 20-30 minutes, depending on the ingredients (chili is a good 30 minutes because of the beans and turkey).  Soaking will improve the flavor and save on fuel.  Add a bit of water here and there so that the food is always absorbing water.

On medium heat, stirring occasionally, heat up your soaked food and add water until it reaches a desired thickness.  Add salt and pepper to taste.  Bring powdered chicken and beef broth with you – add for extra flavour if needed.  Be patient, add a little water at a time and your meal will come back to life beautifully!

The chili was really good, though the portions were a bit small because I used the fifth tray as the tester.  But now that I know it works – 5 trays of chili would fill 4 people perfectly.  And there were no adverse reactions to the black beans!


Dehydrating chicken is super easy – some people cook their chicken and then grate it, but I had a better idea – I used my slow cooker.  I took 5 chicken breasts, marinated it in the Swiss Chalet chicken marinade overnight,  then slow cooked it for 8 hrs.  I syran-wrapped the dehydrator trays and spread out the shredded chicken in a flat layer.  In five hours the chicken was dry – like crackers! – be careful you don’t dehydrate the chicken too much or it will burn.

Dehydration Portage Project 2010


Dehydration Portage Project 2010

I rehydrated the chicken same as above, and made the Swiss Chalet sauce separately.  You can either add the sauce to the chicken for a sort of pulled Swiss chalet chicken, or keep them separate.

Dehydration Portage Project 2010

Rehydrating the chicken

I also had the Swiss Chalet gravy, Idahoan instant mashed potatoes (didn’t require butter or milk) and Stove Top stuffing (I brought 2 x whipped butter).  We also had some Lindt chocolate squares for the smores, and some small packs of raspberry jam (like cranberry sauce), so voila!  Festive Special in Algonquin Park!

Dehydration Portage Project 2010

Swiss Chalet Festive Special


The following recipe was from the March 2001 Bon Appetit magazine, and I added peas for some more protein.

This was one meal where powdered beef broth came in handy – I added a couple of packets on site to give the stew more flavor.

Dehydration Portage Project 2010

Rehydrating Irish beef stew

Dehydration Portage Project 2010

Adding broth to the stew


Dehydration Portage Project 2010

Rehydrated Irish beef stew

The Recipe for Irish Beef Stew modified for dehydrating


1/4 cup vegetable oil

1 1/4 pounds stew beef, cut into 1-inch pieces

1/4 flour

6 large garlic cloves, minced

5 cups beef stock or canned beef broth

2 tablespoons tomato paste

1 tablespoon sugar

1 tablespoon dried thyme

1 tablespoon Worcestershire sauce

2 tablespoons (1/4 stick) butter

3 large russet potatoes, peeled, finely diced

1 large onion, food processed

2 cups carrots, food processed

2 cup dried split peas

salt and pepper

2 bay leaves

2 sprigs fresh parsley

Heat oil in heavy large pot over medium-high heat. Lightly flour the beef and sauté until brown on all sides, about 5 minutes. Add beef stock, tomato paste, sugar, thyme, Worcestershire sauce and bay leaves. Stir to combine. Bring mixture to boil. Pour into crock pot.

Meanwhile, melt butter in another large pot over medium heat. Add garlic, potatoes, onion and carrots. Sauté vegetables until golden, about 20 minutes. Add vegetables & dried peas to beef stew in crock pot and mix.  Place bay leaves in the middle of stew and lay the parsely on top.  Cook on low for 6hrs. Remove bay leaves.  Add salt and pepper to taste.  Blend with hand blender to get rid of any large clumps, being careful not to thicken the stew too much.

Dehydrate as above (you should not need to drain the stew).


Dehydration Portage Project 2010


Jerky was the easiest thing I made!  I actually went to the Asian supermarket and picked up a bag of their thinly sliced beef. It was perfect!  I marinated the beef overnight in 1/4 cup soy sauce, 1-2 tbsp brown sugar (I prefer not too sweet) and 2 tbsp liquid smoke.   I dabbed off any extra marinade before spreading them out evenly on the trays, so I didn’t need any syran wrap. I dehydrated the beef a little too long – 8 hrs – it was still tasty, but a little crunchy.  I think the jerky would have been done around 5-6hrs, so keep an eye on it.

The best thing we did with the jerky on site was to throw it in with our ramen noodles. Delicious!  And don’t forget to bring disposable wooden chopsticks!


  • pick your team well.  Portaging is a lot of work and everyone has to work together no matter how hard the trek or how bad the weather gets.
  • allow a day of rest: the whole point is you want to enjoy the outdoors!  Allow a day of rest in between travel days to enjoy your beautiful campsite.  Or for a shorter route, try to plan so that you have half a day travel, and half a day to enjoy your campsite.
  • bring lots of tarps and rope:  it’s worth the weight.  There’s nothing worse then trying to cook in a downpoor and on sunny days, spread out the tarp and take a nap on your mattress.
  • if the weather has been damp, bring firewood: this, is also worth the weight because there’s no point in trying to start a fire on site if all the surrounding wood is damp.  Make a firewood sling using a climbing sling around your back and fling the loops over your shoulder.  Wear a lifejacket for padding.  Wrap the firewood in a heavy duty garbage bag with duct tape and pass through the loops on your back.  If we are doing a circle route, we will actually hide some wrapped up firewood on the way and pick up on our last night.
  • try the “trip and a half” portage method to save on time: For 4 people: one canoe and one pack walk the whole route. Two packs walk half the route and leave the packs halfway and turn back.  The first two people come back and pick up the two packs at the halfway point.  The last two people pick up the remaining canoe and pack and walk the whole route.
  • get a yolk pad
  • ziplock bag everything (the sliding kind)
  • bring a “personal” 5-10L dry sack.  This will hold anything essential you may need while canoeing: sunscreen, camera, lip balm, kleenex, snacks, hat, sunglasses, rain jacket, purification tablets, binoculars, compass, after bite, musquito repellant – you don’t want to be rummaging through your main pack while canoeing or your canoe will look like a disaster zone.
  • portaging is all about organization: it will make your life so much easier when unpacking and repacking if similar items are grouped together in ziplock bags and packing cubes.
  • get a water proof compression sack for your clothes, sleeping bag – just trust me, it will compress your stuff by half at least
  • use your tent dry sack as a bear bag: no need to bring a barrel for small a weekend portage trip or buy overpriced bear bags – it’s large and waterproof and much more practical
  • bring an extra water bottle: so that one bottle is always purified and ready to go – also you go through a lot of water rehydrating your food
  • don’t forget: toilet paper, baby wipes, purification tables, headlamp + extra batteries, map+ waterproof casing, compass, Imodium, First Aid Kit, Storm Proof matches, fire starters, DEET, sunscreen, afterbite, Camp Suds, extra ziplock bags, duct tape, heavy duty garbage bags, Swiss Army knife, clothespins, portable pot/plate set + sporks, shovel, hatchet, bathing suit, travel towel, sleeping bag + mattress, camera – and my personal favourite: a portable hammock.  Guaranteed to give you the most amazing naps!
  • invest in good rain gear: Goretex hiking boots, waterproof pants and a waterproof rain jacket – not water resistent, waterproof – or you will be miserable.
  • allow one can of fuel (for the solo stove) per day for 4 people
  • pack light: bring an audio book instead of a real book, bring pants that have removable legs, bring a shell that is also a fleece jacket, all your shirts should be quick dry, bring Camp Suds (which can be used as dish soap, body/face wash, laundry soap, shampoo), bring powdered juice + a plastic bottle of alcohol
Dehydration Portage Project 2010

Outdoor kitchen